1995 Ud Ud2300 Recalls

---

NHTSA Campaign Number: 00V059000
Manufacturer: UD TRUCKS CORPORATION
Manufactured Begin Date: September 1st, 1995
Manufactured End Date: June 30th, 1998
Date of Owner Notification: April 17th, 2000

Defect Summary:
VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS. THE DIESEL ENGINE FUEL SHUT OFF SOLENOID CONTAINS INSUFFICIENT WATERPROOF PROTECTION WITH THE ELECTROMAGNETIC SOLENOID COIL WINDINGS.

Consequence Summary:
WATER ENTRY INTO THE INTERNAL COIL WINDINGS OF THE SOLENOID CAN CAUSE THE COIL WINDINGS TO SHORT CIRCUIT AND NOT ALLOW THE VEHICLE TO START.

Corrective Summary:
DEALERS WILL REPLACE THE EXISTING ENGINE STOP SOLENOID WITH A REDESIGNED ENGINE STOP MOTOR AND CABLE ASSEMBLY.

Recall Notes:
OWNER NOTIFICATION BEGAN APRIL 17, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN DIESEL AT 1-972-756-5531. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 96V216000
Manufacturer: UD TRUCKS CORPORATION
Manufactured End Date: August 6th, 1996
Date of Owner Notification: December 6th, 1996

Defect Summary:
THE ELECTRICAL WIRING HARNESS LOCATED TO THE RIGHT OF THE ACCELERATOR PEDAL AND ROUTED ALONG THE ENGINE TUNNEL TO THE DRIVER'S SEAT BASE CAN CHAFE OR RUB BY CONTACT FROM THE DRIVER'S FOOT.

Consequence Summary:
THIS CONDITION CAN CAUSE WIRING HARNESS EXPOSURE OR BREAKAGE OF THE WIRING. THIS WIRING BREAKAGE CAN CAUSE LOSS OF ELECTRICAL POWER TO VARIOUS VEHICLE COMPONENTS OR SYSTEMS INCLUDING THE WINDSHIELD WIPERS.

Corrective Summary:
DEALERS WILL INSTALL A DOUBLE LAYERED PROTECTIVE COVER PERMANENTLY ON THE WIRING HARNESS. IF THE HARNESS OR THE WIRING HAS BEEN BROKEN, IT WILL BE REPAIRED.

Recall Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DECEMBER 2, 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN DIESEL AT 1-972-756-5500.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 95V176000
Manufacturer: UD TRUCKS CORPORATION
Manufactured End Date: February 1st, 1995
Date of Owner Notification: October 10th, 1995

Defect Summary:
THE ELECTRICAL WIRING HARNESS PROTECTOR BEHIND THE BATTERY BOX CAN CHAFE OR RUB ON THE DRIVER'S SIDE LOWER FRAME RAIL FLANGE CAUSING POSSIBLE FAILURE OF THE WIRING HARNESS PROTECTOR AND EXPOSURE OR BREAKAGE OF THE WIRING.

Consequence Summary:
FAILURE OF THE WIRING HARNESS CAN CAUSE LOSS OFELECTRICAL POWER TO VARIOUS VEHICLE COMPONENTS OR SYSTEMS, INCLUDING THE HEADLIGHTS AND WINDSHIELD WIPERS. LOSS OF HEADLIGHTS DURING NIGHTTIME DRIVING OR LOSS OF WINDSHIELD WIPER FUNCTION DURING HEAVY RAIN CAN INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.

Corrective Summary:
DEALERS WILL INSTALL A PLASTIC FRICTION INSULATOR ON THE FRAME RAIL LOWER FLANGE BETWEEN THE FLANGE AND THE WIRING HARNESS PROTECTOR. IF THE PROTECTOR OR ANY OF THE WIRING HAS BEEN BROKEN, IT WILL BE REPAIRED.

Recall Notes:
SYSTEM: ELECTRICAL; WIRING.VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN DIESEL AT 1-214-756-5500. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.