2001 Rhodes Dump Trailer Recalls

---

NHTSA Campaign Number: 04V065000
Manufacturer: RHODES TRAILERS
Date of Owner Notification: February 10th, 2004

Defect Summary:
ON CERTAIN END DUMP TRAILERS EQUIPPED WITH WEBB WHEEL PLATINUM SERIES BRAKE DRUMS, THESE BRAKE DRUMS COULD CRACK ON THE BRAKING SURFACE.

Consequence Summary:
THIS COULD RESULT IN REDUCTION OR COMPLETE LOSS OF BRAKING WHICH COULD RESULT IN A VEHICLE CRASH.

Corrective Summary:
ALL DEALERS AND OWNERS WERE CONTACTED BY TELEPHONE.

Recall Notes:
CUSTOMER'S CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V436000
Manufacturer: RHODES TRAILERS
Date of Owner Notification: September 26th, 2003

Defect Summary:
CERTAIN TRAILERS WERE EQUIPPED WITH SYNTHETIC AXLE GREASE. WHEEL BEARING FAILURE OCCURS RESULTING IN DAMAGED WHEEL HUBS, AXLE SPINDLES, WHEEL SEALS, ETC.

Consequence Summary:
EXTREME HEAT CAN OCCUR THAT COULD CAUSE THE AXLE SPINDLE TO SEPARATE FROM THE AXLE AND CAUSE THE TIRES AND WHEELS TO COME OFF WHILE IN OPERATION, WHICH COULD RESULT IN A CRASH.

Corrective Summary:
DEALERS WILL REMOVE TIRES AND WHEELS, DISASSEMBLE THE AXLE HUB WHEEL BEARINGS, AND INSPECT AND REPLACE, IF NECESSARY. THE SUSPECT GREASE WILL BE REMOVED AND CLEANED THOROUGHLY. OWNER NOTIFICATION BEGAN SEPTEMBER 26, 2003. OWNERS SHOULD CONTACT RHODES AT 1-304-863-8078.

Recall Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V221000
Manufacturer: RHODES TRAILERS
Manufactured Begin Date: January 1st, 1998
Manufactured End Date: December 31st, 2000

Defect Summary:
ON CERTAIN DUMP TRAILERS EQUIPPED WITH SEALCO SPRING BRAKE CONTROL VALVE ASSEMBLIES INCORPORATED IN ARVINMERITOR AXLES, PART NOS. 110700 AND 110800, THERE IS A RECESSED AREA ON TOP OF THE VALVE IN WHICH A BRASS GUIDE PIN FITS DOWN INSIDE THE BODY OF THE VALVE AND IS HELD IN PLACE BY A STEEL SNAP RING. THE RECESSED AREA ALLOWS ACCUMULATION OF WATER, DIRT, AND/OR CHEMICALS TO BUILD UP BEHIND THE SNAP RING TO THE POINT WHERE IT WILL NO LONGER CONTAIN THE GUIDE PIN RESULTING IN A FAILURE OF THE AIR VALVE.

Consequence Summary:
FAILURE OF THE VALVE IN AN EMPTY OR LIGHTLY LOADED TRAILER WHILE THE VEHICLE IS IN MOTION COULD RESULT IN A HARD APPLICATION OF THE SPRING BRAKES, POSSIBLY LOCKING UP THE TRAILER WHEELS AND RESULTING IN A VEHICLE CRASH.

Corrective Summary:
SEALCO WILL PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS TO CUSTOMERS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SEALCO AT 602-253-1007 OR RHODES AT 304-863-8078.

Recall Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).