1999 Orion V Recalls

---

NHTSA Campaign Number: 10V015000
Manufacturer: Daimler Buses North America
Manufactured Begin Date: February 1st, 1992
Manufactured End Date: May 31st, 2009
Date of Owner Notification: April 1st, 2010

Defect Summary:
DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.

Consequence Summary:
THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.

Corrective Summary:
DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.

Recall Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 05V026000
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufacturer Campaign Number: 04C-2
Manufactured Begin Date: July 1st, 1998
Manufactured End Date: December 31st, 1999
Date of Owner Notification: March 1st, 2007

Defect Summary:
ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 50 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO ENTER THE EXHAUST SYSTEM.

Consequence Summary:
IN THE EVENT THE TURBOCHARGER FAILS, A FIRE MAY OCCUR IN THE ENGINE COMPARTMENT RESULTING IN PROPERTY DAMAGE OR INJURIES.

Corrective Summary:
DETROIT DIESEL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPAIR THE ENGINE AND INSTALL AN EXHAUST TEMPERATURE SENSOR TO PREVENT THE POSSIBILITY OF AN EXHAUST OR ENGINE COMPARTMENT FIRE. OWNERS MAY CONTACT DETROIT DIESEL CORPORATION AT 313-592-5791 OR ORION AT 905-403-7832.

Recall Notes:
ORION & DETROIT DIESEL RECALL NO. 04C-2.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 04V545000
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufactured Begin Date: September 1st, 1995
Manufactured End Date: August 31st, 2004
Date of Owner Notification: May 1st, 2005

Defect Summary:
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." DURING SUBSEQUENT CLOSING OF AN EMERGENCY EXIT THE MOVING WINDOW FRAME INTERFERES WITH THE JAM FRAME STOP LOCATED IN MID SPAN ALONG THE LOWER EDGE OF THE WINDOW FRAME.

Consequence Summary:
DURING THE USE OF AN EMERGENCY EXIT WINDOW, A WINDOW MAY NOT OPEN AFTER APPLYING THE REQUIRED FORCES ALLOWING A PERSON TO ESCAPE IN THE EVENT OF AN EMERGENCY.

Corrective Summary:
DEALERS WILL INSTALL TWO ALUMINUM BLOCKS EACH ATTACHED BY TWO SCREWS. THE MOVING WINDOW FRAME WILL NOT INTERFERE WITH THE JAM FRAME STOP. THE RECALL BEGAN MAY 1, 2005. OWNERS SHOULD CONTACT ORION AT 905-403-7832, EXT. 3335.

Recall Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V120000
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufactured Begin Date: January 1st, 1995
Manufactured End Date: December 31st, 2002
Date of Owner Notification: June 2nd, 2003

Defect Summary:
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THE HANDLE PULL FORCE EXCEEDS THE 89N FORCE TO RELEASE THE EMERGENCY WINDOW. ADDITIONAL FORCE IS REQUIRED TO RELEASE THE WINDOW.

Consequence Summary:
IN THE EVENT OF A CRASH, AN OCCUPANT MAY HAVE DIFFICULTY OPENING THE EMERGENCY EXIT WINDOW, INCREASING THE RISK OF PERSONAL INJURY OR DEATH.

Corrective Summary:
DEALERS WILL REPAIR THESE WINDOWS. OWNER NOTIFICATION BEGAN JUNE 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ORION AT 1-800-492-2116.

Recall Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 01V033005
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufactured Begin Date: December 1st, 1998
Manufactured End Date: January 1st, 2000

Defect Summary:
VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.

Consequence Summary:
WITHOUT FUSING, THE EQUALIZER MAY MELT, BURN, OR SMOKE, POSSIBLY RESULTING IN A FIRE OR A SMOKE FILLED BUS, THUS NECESSITATING A PASSENGER EVACUATION OF THE BUS. THE FAILURE MODE CAN CAUSE OPERATOR DISTRACTION, AND/OR POSSIBLE PERSONAL INJURY.

Corrective Summary:
ORION WILL NOTIFY OWNERS TO INSPECT THEIR BUSES FOR CERTAIN EQUALIZERS BY THE DATE CODE. THE AFFECTED EQUALIZERS WILL BE REPLACED BY VANNER. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VANNER AT 1-800-227-6937.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 01V044002
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufacturer Campaign Number: FL-284
Manufactured Begin Date: July 15th, 1999
Manufactured End Date: December 21st, 1999
Date of Owner Notification: May 22nd, 2001

Defect Summary:
VEHICLE DESCRIPTION: TRUCKS, SCHOOL BUS AND MOTOR HOME CHASSIS, AND TRANSIT BUSES EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.

Consequence Summary:
IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:
DEALERS WILL REPLACE THE DEFECTIVE BALL SOCKETS AND/OR DRAG LINKS. OWNER NOTIFICATION BEGAN MAY 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 99V242001
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufacturer Campaign Number: OBI-9901
Manufactured Begin Date: April 17th, 1998
Manufactured End Date: August 2nd, 1999

Defect Summary:
VEHICLE DESCRIPTION: TRANSIT BUSES. FAILURE OF A SOFT SEAT CHECK VALVE IN WHEELCHAIR LIFTS PROVIDED BY LIFT-U, MAY ALLOW THE FRONT AND REAR PLATFORM BARRIERS TO RETURN TO A HORIZONTAL POSITION FROM THE VERTICAL POSITION THEY ARE SUPPOSED TO BE LOCKED IN.

Consequence Summary:
THIS COULD ALLOW A MOBILITY AID TO ROLL OFF OF THE LIFT PLATFORM INJURING ITS OCCUPANT. LIFT-U WILL REPLACE THE SOFT SEAT CHECK VALVES.

Corrective Summary:
LIFT-U WILL REPLACE THE SOFT SEAT CHECK VALVES.

Recall Notes:
ORION RECALL NO. OBI-9901.OWNER NOTIFICATION BEGAN JUNE 25, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT LIFT-U AT 1-209-838-2400 OR ORION BUS AT 1-315-768-8101.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).