1999 Holiday Rambler Alumascape Recalls

---

NHTSA Campaign Number: 04V483000
Manufacturer: MONACO COACH CORPORATION
Manufacturer Campaign Number: R02233
Manufactured Begin Date: June 15th, 1998
Manufactured End Date: July 11th, 2003
Date of Owner Notification: October 29th, 2004

Defect Summary:
ON CERTAIN FIFTH WHEEL TRAILERS, A DEFICIENCY IN THE STRUCTURAL INTEGRITY OF THE MAIN FRAME RAILS COULD CAUSE THE RAILS TO CRACK AND AXLES COULD SHIFT, CAUSING THE FIFTH WHEEL TO PULL ERRATICALLY.

Consequence Summary:
THIS COULD CAUSE THE DRIVER OF THE TOW VEHICLE TO LOSE CONTROL CREATING THE POTENTIAL FOR A CRASH RESULTING IN PERSONAL INJURY.

Corrective Summary:
DEALERS WILL INSPECT AND ADD AN ADDITION OF GUSSET PLATES AND CROSS TUBES TO STRENGHEN THE AXLE SPRING HANGERS. THE RECALL BEGAN ON OCTOBER 29, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Recall Notes:
MONACO RECALL NO. R02233.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V166000
Manufacturer: MONACO COACH CORPORATION

Defect Summary:
ON CERTAIN MOTORHOMES, FIFTH WHEELS AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM, THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK.

Consequence Summary:
IF A LEAK OCCURS AND THE UNIT IS CONTINUALLY OPERATED, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Corrective Summary:
NORCOLD WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPLACEMENT COOLING UNIT FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-667-3005 OR MONACO AT 574-862-7211.

Recall Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 01V112000
Manufacturer: MONACO COACH CORPORATION
Manufactured Begin Date: July 1st, 1998
Manufactured End Date: April 24th, 2001
Date of Owner Notification: June 5th, 2001

Defect Summary:
VEHICLE DESCRIPTION: TRAVEL TRAILERS AND FIFTH WHEEL TRAILERS. A WIRE SUPPLYING 12VOLT DC TO THE HOLDING TANK MONITORING SYSTEM DISPLAY PANEL WAS INSTALLED WITHOUT PROPER CIRCUIT PROTECTION. THE CIRCUIT IS CONNECTED TO THE VOLTAGE SOURCE WITH A 12VOLT DC 50 AMP SELF-RESETTING CIRCUIT BREAKER AS PROTECTION AGAINST AN ELECTRICAL SHORT TO GROUND.

Consequence Summary:
AN ELECTRICAL SHORT COULD OCCUR.

Corrective Summary:
DEALERS WILL INSTALL A 6-AMP CIRCUIT BREAKER ON THE 12VOLT DC WIRE SUPPLYING VOLTAGE TO THE HOLDING TANK MONITOR PANEL DISPLAY. OWNER NOTIFICATION BEGAN JUNE 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).